Removing Commercial Beer Labels - Home Brew Forums
Register Now For Free!

Home Brew Forums > Home Brewing Beer > Bottling/Kegging > Removing Commercial Beer Labels

Reply
 
Thread Tools
Old 03-03-2008, 07:51 PM   #1
rurounikitsune
Recipes 
 
Feb 2008
Posts: 101
Liked 2 Times on 2 Posts



Once upon a time, I was trying to get the labels off some Dark Horse Brewery bottles so I could reuse them. I painstakingly scratched the labels off with a credit card. Then, after half an hour, steel wool, Brillo, detergent, and acetone, nothing worked to remove the adhesive goo where the label had been. I told SWMBO to get a different solvent. She came up with vegetable oil. I laughed at her.

So, long story short, if you want to get the label goo off a commercial beer bottle and nothing else is working, you might try this method. Soak it in warm water to weaken the paper and then peel off as much as you can. Then use a paper towel to apply cheap vegetable oil to all the goo that is left over. You will know if it is working because the goo is gone. The oil dissolves the adhesive immediately. The paper towel wipes it off effortlessly. It only works if you wet, weaken, and tear off the top layer of the paper (which is not that hard). The oil will only dissolve the adhesive it can actually get to. If there is a thin layer of paper, a little rubbing with a paper towel might get the oil to soak through the paper (if it is thin and weak enough) and it will come off easily.

If the bottle feels oily afterward, a grease-cutting dish detergent will remove the oil as fast as the oil removed the goo. Then I clean the inside of the bottles just in case anything made it in. I have to clean the inside anyway so it works out nicely. Using this method I can pour myself a glass of Sam Adams, and have the bottle cleaned, delabeled, and ready for sanitization before the head is gone. No overnight soaking, no expensive cleaning solutions, no nothing.

Campero Likes This 
Reply With Quote
Old 03-03-2008, 07:53 PM   #2
taydawg197
Recipes 
 
Jul 2007
Posts: 38

I have heard that if you put a little milk in with the water and soak the bottles for a little bit they peel off effortlessly, leaving no goo. I haven't tried this but a guy at my LHBS let me in on the "secret"

-Matt

 
Reply With Quote
Old 03-03-2008, 07:53 PM   #3
Revvy
Post Hoc Ergo Propter Hoc
HBT_LIFETIMESUPPORTER.png
 
Revvy's Avatar
Recipes 
 
Dec 2007
"Detroitish" Michigan
Posts: 40,926
Liked 3201 Times on 1889 Posts


Have you tried oxyclean and hot water? Bottles come clean in anywhere between 1 and 48 hours depending on the toughest glue. The labels just float to the surface. Goo remnents rinse right off.
__________________
Like my snazzy new avatar? Get Sons of Zymurgy swag, here, and brew with the best.

Revvy's one of the cool reverends. He has a Harley and a t-shirt that says on the back "If you can read this, the bitch was Raptured. - Madman

I gotta tell ya, just between us girls, that Revvy is HOT. Very tall, gorgeous grey hair and a terrific smile. He's very good looking in person, with a charismatic personality... he drives like a ****ing maniac! - YooperBrew

 
Reply With Quote
Old 03-03-2008, 07:55 PM   #4
Beerthoven
Recipes 
 
May 2007
Cary, NC
Posts: 2,176
Liked 36 Times on 31 Posts


Thanks for the tip! I normally soak my bottles in hot water and oxy-clean and most labels float right off. But every once in a while there's a bottle or two with some sticky glue on it that won't come off. I'll be sure to try this when that happens.

__________________

Primary/Secondary: #133 Scottish 80/-
Kegged: #132 American Wheat
Planned: IPA, Brown, Pale Ale

 
Reply With Quote
Old 03-03-2008, 07:57 PM   #5
Soulive
 
Soulive's Avatar
Recipes 
 
Mar 2007
The Middle of NJ
Posts: 4,278
Liked 25 Times on 25 Posts


I used to soak in Oxyclean and then scrub briefly with a Chore Boy. The abrasiveness usually removed the leftover glue pretty easily...
__________________
Cheers!


===================
Green Lane Brewing
===================

Primary = Evan!'s Special Bitter
On Deck = EdWort's Porter / American Amber


EdWort's Haus Pale Ale Count

 
Reply With Quote
Old 03-03-2008, 11:23 PM   #6
malkore
 
malkore's Avatar
Recipes 
 
Jun 2007
Nebraska
Posts: 6,922
Liked 37 Times on 35 Posts


+1 to oxyclean, but Star San is also good at removing labels, especially the newer clear ones. and it can remove painted on labels too I have heard.
__________________
Malkore
Primary: English Mild
On tap: Pale Ale, Lancelot's Wheat, English Brown Ale, Steam Beer, HoovNuts IPA
Bottled: MOAM, Braggot, Raspberry Melomel, Merlot, Apfelwein, Pyment, Sweet mead, Cabernet
Gal in 2009: 27, Gal in 2010: 34, Gal in 2011: 13, Gal in 2012: 10

 
Reply With Quote
Old 03-04-2008, 01:48 AM   #7
Poindexter
 
Poindexter's Avatar
Recipes 
 
Oct 2007
interior Alaska
Posts: 1,195
Liked 5 Times on 5 Posts


I will try this on a couple White Yeast tubes I kept, and a stubborn Sierra Nevada bottle that will not beat me.

 
Reply With Quote
Old 03-04-2008, 02:15 AM   #8
Bullbythehorns
 
Bullbythehorns's Avatar
Recipes 
 
Dec 2007
Lake of the Ozarks, MO
Posts: 150
Liked 5 Times on 4 Posts


Another alternative is a quick soak in warm water and ammonia. The labels and glue come off very quickly and easily.

 
Reply With Quote
Old 03-04-2008, 02:40 AM   #9
mullimat
Recipes 
 
Feb 2008
Frederick, MD
Posts: 330
Liked 9 Times on 1 Posts


I have found that throwing the bottles REALLY hard at a brick wall gets the labels off super quick!

9
People Like This 
Reply With Quote
Old 03-07-2008, 04:11 PM   #10
rurounikitsune
Recipes 
 
Feb 2008
Posts: 101
Liked 2 Times on 2 Posts


Just cleaned all the goo off our wooden dining room table with cheap vegetable oil. SWMBO is really impressed with it. One less thing to use chemicals for! It does even better on wood because it soaks in and buffs out nicely and you don't have to worry about rinsing it off.

 
Reply With Quote
Reply
Thread Tools


Similar Threads
Thread Thread Starter Forum Replies Last Post
Removing labels from beer bottles. jpass00 Bottling/Kegging 113 06-10-2015 03:42 PM
Removing Labels philosofool Bottling/Kegging 12 01-28-2009 09:47 PM
Removing labels from commercial bottles mjs483 General Techniques 19 02-15-2008 04:49 PM
Removing Labels? humboldthomebrew Label Display & Discussion 22 10-14-2006 01:46 AM
removing labels with beer in it... deranged_hermit Bottling/Kegging 6 03-06-2006 01:54 AM


Forum Jump