Fermentation Chamber Heater Needed? - Home Brew Forums
Home Brew Forums > Home Brewing Beer > Beginners Beer Brewing Forum > Fermentation Chamber Heater Needed?
Cool Brewing Giveaway - Supporting Membership Drive & Discount

Reply
 
Thread Tools
Old 12-01-2012, 03:44 PM   #1
PackerfaninSanDiego
Member
HBT_SUPPORTER.png
 
PackerfaninSanDiego's Avatar
Recipes 
 
Oct 2012
Ramona, California
Posts: 1,584
Liked 182 Times on 137 Posts



I just got a 7cuft GE Chest Freezer,,along with a Johnson Controller. I live in Ramona, Ca. where in the winter it can get below freezing during the night but never during the day. Seeing that the temp could be below freezing for a few hours, is there a need to have an "aquarium" type heater?
My freezer will be in the garage. Something tells me that I should not need a heater.


__________________
"Was it over when the Germans bombed Pearl Harbor?"

 
Reply With Quote
Old 12-01-2012, 04:15 PM   #2
pogden
HBT_SUPPORTER.png
Recipes 
 
Dec 2011
Phoenix, Arizona
Posts: 118
Liked 13 Times on 9 Posts


Not sure whether you will "need" one, but ... the goal is to keep the fermentation temperature as constant as possible. As the temperature in your garage drops below your fermentation temperature, so will the temperature in your freezer. If, during a cold snap your garage stayed at 45-50 degrees for a week or more, the temperature of your fermenting beer would probably get pretty close to that, and that's probably not what you want.

After a bit of research (mainly on HBT) I bought a Brewer's Edge space heater from William's Brewing. It may not be the least expensive option ($35) but it's nice, takes up no room, and comes with adhesive backing for mounting to the wall of your freezer.



 
Reply With Quote
Old 12-01-2012, 04:20 PM   #3
hillhousesawdustco
HBT_LIFETIMESUPPORTER.png
 
hillhousesawdustco's Avatar
Recipes 
 
Jan 2011
up near babb, mt
Posts: 647
Liked 35 Times on 34 Posts


Any old space heater with a temp controller will work, or you could get one with. Built in thermostat (check it, sometimes they are 5-10 degrees off!) some people just use a lightbulb or a greenhouse-style heated mat.

 
Reply With Quote
Old 12-01-2012, 04:27 PM   #4
PackerfaninSanDiego
Member
HBT_SUPPORTER.png
 
PackerfaninSanDiego's Avatar
Recipes 
 
Oct 2012
Ramona, California
Posts: 1,584
Liked 182 Times on 137 Posts


The controller will turn on the compressor when temp gets above "designated" temp?
The freezer is insulated like a Igloo cooler?
Is there a device to tell me the inside temp without opening the lid and reading a thermometer?
__________________
"Was it over when the Germans bombed Pearl Harbor?"

 
Reply With Quote
Old 12-01-2012, 04:40 PM   #5
rustym
Recipes 
 
Dec 2010
Rock Hill, SC
Posts: 275
Liked 26 Times on 21 Posts


You'll need a heater. Especially if you want to ferment any Belguim-Type beers and you want to ramp up the temperature to 75 or so. Even when I do an ale i like to start out on the low side of fermentation temps and then towards the end bump it up to ~70. This time of the year you have to have some sort of heat.

I actually built one of these: http://http://www.wortomatic.com/art...ion-Can-Heater, and it worked great but I wanted to have some airflow in my chamber so I bought one of these: http://http://www.walmart.com/ip/Las...eater/16503222.

You can get them at Walmart for $11, not 18. I really like it. I hook it to my temperature controller on the heat cycle and set it for 70 and when it runs it also circulates air which I think keeps the inside of your chamber from getting stale.

 
Reply With Quote
Old 12-01-2012, 04:44 PM   #6
oakbarn
HBT_LIFETIMESUPPORTER.png
 
oakbarn's Avatar
Recipes 
 
Jun 2011
Argyle, Texas
Posts: 805
Liked 58 Times on 46 Posts


You can use a PID from auberins and an SSR to control a freezer using a light bulb as the heat sources. The Johnson will only control one side (like all Johnsons, it is single minded!)

 
Reply With Quote
Old 12-01-2012, 04:49 PM   #7
mgortel
Recipes 
 
May 2010
Stewartstown, PA
Posts: 861
Liked 48 Times on 37 Posts


I use a 7cu ft chest freezer as well..and the Johnson Temp Controller..and its in my garage....and I also use the My heat Personal Heater from Walmart....$12.00 Works great.

I have the sensor sitting in my chest freezer about mid height (away from the wall), and I set the heater on the high end of freezer (where compressor is) and plug into temp controller. Works like a charm!

One bit of warning though....during the first couple of days when the fermentation is rocking...the chamber got a little warmer than I wanted on my first use of this setup....because there was so much heat generation from the yeasties....so now I put a 3/4" block of wood under lid to prop it open to let any excess heat out....during the first couple of days. The heater will still maintain temperature with no problem....but if too much heat builds up it will allow it to escape. Once the initial fast rate fermentation is over I remove block.

Oh yeah...like another poster said....make sure to set your controller to heating mode....

here is another option for heater....but it is more expensive....

http://www.williamsbrewing.com/BREWE...-P518C100.aspx
__________________
EVERYONE is entitled to my opinion!
Primary: None
Secondary: Chocolate milk Stout
Upcoming Brews: Dusseldorf Alt
Kegged: Biermuncher Centenniel Blonde

 
Reply With Quote
Old 12-01-2012, 05:11 PM   #8
PackerfaninSanDiego
Member
HBT_SUPPORTER.png
 
PackerfaninSanDiego's Avatar
Recipes 
 
Oct 2012
Ramona, California
Posts: 1,584
Liked 182 Times on 137 Posts


So the Johnson Controller will allow the freezer to turn on when the set temp gets to warm........but what will control the heater?
__________________
"Was it over when the Germans bombed Pearl Harbor?"

 
Reply With Quote
Old 12-01-2012, 05:24 PM   #9
rjbank
HBT_SUPPORTER.png
Recipes 
 
Dec 2011
Posts: 138
Liked 47 Times on 28 Posts


You need a two stage temp controller. Johnson control makes one for about $100

 
Reply With Quote
Old 12-01-2012, 05:26 PM   #10
mgortel
Recipes 
 
May 2010
Stewartstown, PA
Posts: 861
Liked 48 Times on 37 Posts


Yep...if you need to control freezer and heater....you will need a dual controller or buy another A419 and use one for heater and one for freezer.....

More economical to buy the dual controller of course.....


__________________
EVERYONE is entitled to my opinion!
Primary: None
Secondary: Chocolate milk Stout
Upcoming Brews: Dusseldorf Alt
Kegged: Biermuncher Centenniel Blonde

 
Reply With Quote
Reply
Thread Tools


Similar Threads
Thread Thread Starter Forum Replies Last Post
Fermentation Chamber Heater mgortel Fermentation & Yeast 25 11-16-2012 06:11 PM
fermentation chamber heater? BLM Fermenters 17 04-08-2011 06:38 PM
Fermentation chamber heater Bugaboo Fermenters 4 08-28-2010 06:26 AM
Fermentation Chamber Heater mattlins Fermenters 23 04-28-2010 06:46 PM
Heater for fermentation chamber dunleav1 Fermenters 7 04-08-2009 11:27 PM


Forum Jump