Electric HLT Keg - Home Brew Forums
Register Now For Free!

Home Brew Forums > Home Brewing Beer > Electric Brewing > Electric HLT Keg

Reply
 
Thread Tools
Old 04-05-2011, 08:11 AM   #1
drunkenmonkeybrewing
Recipes 
 
Apr 2011
Omaha, Nebraska
Posts: 4


Okay, so I'm assuming this question has been asked and answered before, but since I'm browsing at dial-up speeds I'll ask it again. I want to use either the Johnson A419 or the Ranco ETC-111000 on my HLT. I'm not partial to either one, they just fall in the affordability and ease of use category.
I'm no electrician, but I believe that I have 240v running to my garage. What kind of heating element will work with the controls above, fit in a keg (mounted horizontally), and can heat 12 gallons of water in a reasonable (an hour or less) amount of time?

 
Reply With Quote
Old 04-05-2011, 11:46 AM   #2
onthekeg
Recipes 
 
Feb 2009
Posts: 1,786
Liked 83 Times on 65 Posts


I think you would be better off using an Auber PLC, and an SSR with a 5500w element in the HLT than messing with the two choices you shown, as it would be cheaper and allow more control.

 
Reply With Quote
Old 04-05-2011, 01:52 PM   #3
drunkenmonkeybrewing
Recipes 
 
Apr 2011
Omaha, Nebraska
Posts: 4

Thanks for the quick reply. I think that the PLC is a bit overkill for what I require. I just need to heat the HLT and maintain the temp for a HERMs setup. My boil kettle will propane. Besides, my electronic skills are pretty nil.
I can either run 120v or 240v to the set up. Any ideas?

 
Reply With Quote
Old 04-05-2011, 02:45 PM   #4
UNOmar
Recipes 
 
Feb 2006
Omaha, NE
Posts: 109

I'm considering a similar setup for my rig. My garage already has a 15A 120v circuit run so I've been contemplating using water from the water heater (approx. 125F) and then heating that with a 1440 watt element. I figure that should be enough to raise temps in a reasonable amount of time and it keeps costs down.
If I decide to pull from a non-heated source I'll probably end up running a 30A 240v circuit as that gives me more options down the road. My dream would be to have a Kal style setup, but I doubt the SWMBO would give financial approval to that.

Not sure if that helps you any, but just figured I'd throw in my $0.02.

-UNOmar
__________________
UNOmar

 
Reply With Quote
Old 04-05-2011, 03:46 PM   #5
Monster Mash
Recipes 
 
Apr 2006
Castaic, CA
Posts: 1,323
Liked 93 Times on 72 Posts


Quote:
Originally Posted by drunkenmonkeybrewing View Post
Thanks for the quick reply. I think that the PLC is a bit overkill for what I require. I just need to heat the HLT and maintain the temp for a HERMs setup. My boil kettle will propane. Besides, my electronic skills are pretty nil.
I can either run 120v or 240v to the set up. Any ideas?
You can use either of those controllers but you will still need to run an SSR off of the relay in the controller. For a 240v element I would run two SSR's to switch both legs of power.
__________________
My 1BBL Brewery Pics

 
Reply With Quote
Old 04-05-2011, 06:53 PM   #6
drunkenmonkeybrewing
Recipes 
 
Apr 2011
Omaha, Nebraska
Posts: 4

Thanks for all of the replies above. Since it seems that I'm going to need an SSR or two regardless, how about the following?

40 A SSR
Control Box
PID Temperature Controller (SSR control output)

 
Reply With Quote
Old 04-05-2011, 07:06 PM   #7
Walker
I use secondaries. :p
HBT_LIFETIMESUPPORTER.png
 
Walker's Avatar
Recipes 
 
Sep 2005
Cary, NC
Posts: 10,987
Liked 101 Times on 89 Posts


don't forget a temp probe and a heatsink for the SSR
__________________
Ground Fault Brewing Co.

 
Reply With Quote
Old 04-05-2011, 08:06 PM   #8
drunkenmonkeybrewing
Recipes 
 
Apr 2011
Omaha, Nebraska
Posts: 4

Thanks. I haven't forgotten.

 
Reply With Quote
Reply
Thread Tools


Similar Threads
Thread Thread Starter Forum Replies Last Post
I want to make an electric MLT... Beavdowg Electric Brewing 9 09-14-2011 10:25 PM
Electric Brewstand JoeBuch Electric Brewing 24 01-18-2011 07:27 PM
new to electric brewing Q's HH60gunner Electric Brewing 6 12-13-2010 11:40 PM
3E Brewery going ELECTRIC!!! EuBrew Electric Brewing 17 10-28-2010 05:12 PM
electric brewery help RedBarnBrewing Electric Brewing 5 10-23-2010 02:28 AM


Forum Jump