Belgian cork into champagne bottle - Home Brew Forums
Home Brew Forums > Home Brewing Beer > Bottling/Kegging > Belgian cork into champagne bottle

Reply
 
Thread Tools
Old 01-19-2011, 04:43 PM   #1
McKinley
Recipes 
 
May 2010
Bethesda
Posts: 57
Liked 1 Times on 1 Posts



Has anyone used a belgian (~25 mm) cork in a 750 mL/29 mm cap size champagne bottle?

Using the ferrari corker and a lot of F-words I've bottle champagne bottles w/ champagne corks just fine. The problem is that the champagne corks are hard to come by, and cost about $ 0.45/cork, which adds up. I have a source for belgian corks that's much cheaper @ around $ 0.16/cork, but my LHBS doesn't carry belgian bottles, at its expensive to ship glass.

So the cheapest thing would be to use belgian corks with champagne bottles, but I'm worried the smaller cork size will leave me with a bunch of flat ciders and belgian beers.

Any thoughts?



 
Reply With Quote
Old 01-20-2011, 08:05 AM   #2
StMarcos
Recipes 
 
Apr 2008
Sebastopol, CA
Posts: 971
Liked 34 Times on 27 Posts


You can use the belgian corks in standard 22oz bombers. They don't explode at 3 volumes at room temperature in my experience. Or... start drinking belgians and save the bottles. When I gift 'em, I usually ask for the bottles back. Find a bar that sells bottled belgians. Go in on a Saturday and ask to scavenge the recycling. It's nice to not have the chimays with the paint though. A sharpie works great for twisting the hoods. Scrunch the 4 vertical wires into rough position before twisting. I've never had a cork fly out of a beer after removing the hood, but it did happen with a champagne once.



 
Reply With Quote
Old 01-21-2011, 08:19 PM   #3
McKinley
Recipes 
 
May 2010
Bethesda
Posts: 57
Liked 1 Times on 1 Posts


Quote:
Originally Posted by StMarcos View Post
Find a bar that sells bottled belgians. Go in on a Saturday and ask to scavenge the recycling.
That's a good idea, thanks!

 
Reply With Quote
Old 01-26-2011, 06:32 PM   #4
McKinley
Recipes 
 
May 2010
Bethesda
Posts: 57
Liked 1 Times on 1 Posts


So I figured out the answer is that yes, belgian corks will hold pressure in a standard champagne bottle. I've got two points of evidence to support this:

I purchased a bottle of Westmalle in a 750 mL champagne style bottle with a belgian cork. I measured the opening with calipers and found it was the same diameter as several different kinds of commercial champagne bottles I've saved from New Years. Since the beer was obviously carbonated using a belgian cork, I could have stopped right there. But since I've got too much time on my hands right now, I took 1 L of water and rehydrated a pack of pasteur champagne. I then added enough sugar to prime the liter for 6.2 volumes. 750 mL of this "delicious brew" went into a champagne bottle from Mumm with a 25 mm belgian cork and wire cage. I let this ferment out over about a week, then opened it, foolishly, at room temp. This resulted in a nice yeast-water gyser in my kitchen. The water was appropriately spritzy, and tasted exactly like you can imagine a warm slurry of yeast and water would taste like.

ten80 Likes This 
Reply With Quote
Old 01-24-2016, 05:13 PM   #5
tonymark
Recipes 
 
Dec 2012
Atlanta, Ga
Posts: 94
Liked 3 Times on 3 Posts


Not all champagne/sparkling wine bottles are created equal. I collect empties for beers. I had some that seemed light so I weighed several. Mass ranged from 560 grams to over 900 grams. The better French brands were on the higher side. Be careful with lighter bottles.



ten80 Likes This 
Reply With Quote
Reply
Thread Tools


Similar Threads
Thread Thread Starter Forum Replies Last Post
Plastic Champagne Corks -- can be used to cork champagne and Belgian 750ml bottles ReverseApacheMaster Bottling/Kegging 10 12-09-2010 03:42 AM
bottle caps with a cork insert Cryersen Bottling/Kegging 2 09-18-2010 11:02 PM
cork shot off conditioning bottle schristian619 Bottling/Kegging 4 08-19-2010 01:03 PM
Where to get 12oz Belgian Cork Bottles Zen_Brew Bottling/Kegging 8 03-29-2010 05:05 AM
Belgian Bottle Wire Cork Hoods SALE B-Dub Bottling/Kegging 0 03-05-2009 03:11 AM


Forum Jump