impulserush

Recipes 

What is the best way to sanitize the bottles before bottling. I will not use a dish washer. When I clean by beer bottles I dissolve B-Bright in the sink, brush cean and hot water rinse. What would be the best to clean wine bottles.Potassium Metabisulphate?

What would be the best steps, The same as I do with beer bottles. I am looking for a quick, efficent, clean way to do so. I do have a bottle driying rack.

Thanks for the help.

__________________
PENNSYLVANIA REDNECK HOME BREWER!

Primary: Empty
Secondary: Empty
Drinking:Belgian Wit. Hophead IPA, Weyerbacher Big Brews

Wine:
Primary: Empty
Drinking: Pomigranite Zin.Black Berry Merlot

LastKnight

Recipes 

Star*San for the win! I fill my bottling bucket with five gallons of Star*San and water, and siphon it into my bottles - sanitizing everything I need for the bottling at once.

impulserush

Recipes 

Thanks, Will Look Into That.

__________________
PENNSYLVANIA REDNECK HOME BREWER!

Primary: Empty
Secondary: Empty
Drinking:Belgian Wit. Hophead IPA, Weyerbacher Big Brews

Wine:
Primary: Empty
Drinking: Pomigranite Zin.Black Berry Merlot

LastKnight

Recipes 

Mind, that's just for sanitizing. If you have goop in your bottles, or things crusted to the bottom, I've heard Oxyclean mentioned favorably on this and other forums. A nice long soak might be just what it needs.

impulserush

Recipes 

Star san need to be rinsed then?

__________________
PENNSYLVANIA REDNECK HOME BREWER!

Primary: Empty
Secondary: Empty
Drinking:Belgian Wit. Hophead IPA, Weyerbacher Big Brews

Wine:
Primary: Empty
Drinking: Pomigranite Zin.Black Berry Merlot

ClutchDude

Recipes 

No. Star san is a rinseless foam sanitizer. Fill the bottles with star san then empty back into the bucket or whatever. Star san can be reused(just check out the beer-side of the forum for more info on Star san).

Let them dry until most of the foam is gone and then fill.

DON'T FEAR THE FOAM.

__________________

Landed In Texas.
Primary 1: St. Faud's Irish, 8/12/2012
Primary 2: Empty
3 Gal: Always Apfelwein; 1/18/2012
6 Gal: Empty
Kegged/Bottled: Blueberry Wine 6/12/08
Sanke madness!
Sanke Spiral Ring Installing, Sanke Coupler diassembly, Keggle Heatshield, Sanke fitting to Soda kegs

dagamore

Recipes 

one of the great purchases for sanitation is the Sanitizer Injector like the one found here

Sanitizer Injector | MoreBeer

It fits right on top of a bottle tree like found here.

Rotating Bottle Tree (45 Bottle) | MoreBeer

mix up just a little bit of StarSan or Iodine no rinse sanitizer such as found here

IO Star Iodine Sanitizer 32 oz | MoreBeer

Star San HB High Foam Acid Anionic Cleaner & Final Rinse (8 oz) | MoreBeer

i make up about 4 or 5 cups of sanitizer and it will sanitize 50ish 1L bottles twice with out any issues.

I just pour the sanitizer in the the bowl at the top and then spray the inside of the bottle 3 or 4 times, once through all the bottles(note it only needs 30 seconds contact to sanitize(two minutes is an FDA rule(its done in 30 seconds))) and then i run them through again, and still have a lot of sanitizer left. Never had any issues with with an infection.

danorocks17

Recipes 

I fill my bottling bucket with Idophor and put my clean bottles in that. I can fit about 18 bottles in it, let them sit for 5-10 min, then drain them back into the bucket and set upside down in the case, or on your drying rack.

__________________
Burning Fence Brewery

"blessing of your heart, you brew a good ale"

impulserush

Recipes 

I bought the injector and Potassium Metabisulphate from the local wine store. He did not have star san. He did say that he uses this all the time with no problem. My next question is what would be a good sanitizer for bottling beer. I have used B-Bright. I was told this is a cleaner not a sanitizer.

Thanks for your help

__________________
PENNSYLVANIA REDNECK HOME BREWER!

Primary: Empty
Secondary: Empty
Drinking:Belgian Wit. Hophead IPA, Weyerbacher Big Brews

Wine:
Primary: Empty
Drinking: Pomigranite Zin.Black Berry Merlot

malkore

Recipes 

again, star-san. star-san star-san star-san. its the bees knees of santizers. if your LHBS doesn't carry it, ask them to, or order it online (though the store is foolish not to carry star-san).

__________________
Malkore
Primary: English Mild
On tap: Pale Ale, Lancelot's Wheat, English Brown Ale, Steam Beer, HoovNuts IPA
Bottled: MOAM, Braggot, Raspberry Melomel, Merlot, Apfelwein, Pyment, Sweet mead, Cabernet
Gal in 2009: 27, Gal in 2010: 34, Gal in 2011: 13, Gal in 2012: 10